Landfill Gas Recovery
Introduction
The waste deposited in a landfill gets subjected, over a period of time, to anaerobic conditions and its organic fraction gets slowly volatilised and decomposed, leading to production of landfill gas which contains a high percentage of methane (about 50%).
Typically, production of landfill gas starts within a few months after disposal of wastes and generally lasts for 10 years or even more depending upon mainly the composition of wastes and availability of moisture. As the gas has a calorific valve of around 4500 Kcal/m3, it can be used as a source of energy either for direct heating/ cooking applications or to generate power through IC engines or turbines.
Advantages of Landfill Gas Recovery
- Reduced GHG emissions;
- Low cost means for waste disposal; and
- The gas can be utilised for power generation or as domestic fuel.
Disadvantages
- Inefficient gas recovery process yielding only 30-40% of the total amount of gas actually generated. Balance gas escapes to the atmosphere (significant source of two major green house gases, carbon-dioxide and methane);
- Utilisation of methane may not be feasible for remote sites;
- Cost of pre-treatment to upgrade the gas may be high; and
- Spontaneous ignition / explosions may occur due to possible build up of methane concentrations in atmosphere.
Limitations/ Constraints
The growth of this sector has been affected on account of the following limitations/ constraints:
- Waste-to-Energy is still a new concept in the country;
- Most of the proven and commercial technologies in respect of urban wastes are required to be imported;
- The costs of the projects especially based on biomethanation technology are high as critical equipment for a project is required to be imported.
- In view of low level of compliance of MSW Rules 2000 by the Municipal Corporations/ Urban Local Bodies, segregated municipal solid waste is generally not available at the plant site, which may lead to non-availability of waste-to-energy plants.
- Lack of financial resources with Municipal Corporations/Urban Local Bodies.
- Lack of conducive Policy Guidelines from State Govts. in respect of allotment of land, supply of garbage and power purchase / evacuation facilities.
Financial Support
The scheme for providing financial support for waste-to-energy projects is presently under review and accelerated programme on energy recovery from municipal and industrial wastes is being development for providing a major fillip to this sector.
Implementation
Waste-to-energy projects can be set up municipal corporations, other urban local bodies, government institutions, and private developers having technical and managerial capabilities for implementing such projects on the basis of Build, Own, and Operate (BOO); Build, Own, Operate, and Transfer (BOOT); Build, Operate, and Transfer (BOT); and Build, Operate, Lease, and Transfer (BOLT). The proposals are to be sent to the MNES after completing all tie-ups for waste procurement, sale and evacuation of power, pollution control, etc. In cases where debt financing is involved, IREDA, other financial institutions, and commercial banks are required to forward proposals alone with their Appraisal Note. An advance copy of the proposal may be sent to the MNES.
Potential
There exists a potential for generating an estimated 1700 MW of power from the urban and municipal waste, and about 1000 MW from industrial wastes in the country. The potential is likely to increase further with economic development.
Achievements
A total of 27 waste-to-energy projects have been completed as on 31 March 2005 in India, with an aggregated installed capacity of 45.50 MW. In table gives the state-wise cumulative achievements as on 31 March 2005.
Cumulative achievements as on 31 March 2005
State |
Achievement (MW) |
| Andhra Pradesh | 25.10 |
| Gujarat | 2.95 |
| Karnataka | 1.00 |
| Madhya Pradesh | 2.73 |
| Maharashtra | 1.90 |
| Orissa | 0.03 |
| Punjab | 1.75 |
| Tamil Nadu | 1.98 |
| Uttar Pradesh | 8.00 |
Total |
45.44 |
Main Application
Energy Recovery from Wastes
For further information please contact
Ministry of Non-Conventonal Energy Sources,
Govt. of India
Block-14, CGO Complex, Lodi Road
New Delhi – 110 003
Tel: 91 11 2436 0707/ 2436 0404
Fax: 91 11 2436 1298
