Plasma Arc
Introduction
Plasma arc technology is a relatively new technology for disposal of wastes, particularly, hazardous and radioactive wastes. This technology is now being seen as an attractive option for disposal of MSW as well. Besides generating energy, plasma arc technology ensures the near-complete destruction of waste. Therefore, it has an edge over the combustion processes described earlier. The major advantages of plasma arc technology are listed below.
- Compared to combustion/incineration technology, it creates much less atmospheric pollution.
- In techno-economic terms, oxides of nitrogen and sulphur are not emitted during normal operations because the system works in absence of oxygen.
- Toxic materials become encapsulated and are therefore much safer to handle than the toxic ash left by combustion/gasifier processes.
Despite these advantages, however, plasma arc technology is costly, and has not been tried in India
Advantages
The major advantages of setting up of waste-to-energy projects are
- The quantity of waste gets reduced by nearly 60% to 90%, depending upon the waste composition and the technology adopted
- Demand for land, which is already scarce in cities, for land filling is reduced;
- The cost of transportation of waste to far-away landfill sites gets reduced; and
- There is net reduction in environmental pollution
- Apart from generating power from the waste, the slurry produced from biomethanation technology acts as a good fertilizer
Limitations/ Constraints
The growth of this sector has been affected on account of the following limitations/ constraints:
- Waste-to-Energy is still a new concept in the country;
- Most of the proven and commercial technologies in respect of urban wastes are required to be imported;
- The costs of the projects especially based on biomethanation technology are high as critical equipment for a project is required to be imported.
- In view of low level of compliance of MSW Rules 2000 by the Municipal Corporations/ Urban Local Bodies, segregated municipal solid waste is generally not available at the plant site, which may lead to non-availability of waste-to-energy plants.
- Lack of financial resources with Municipal Corporations/Urban Local Bodies.
- Lack of conducive Policy Guidelines from State Govts. in respect of allotment of land, supply of garbage and power purchase / evacuation facilities.
Financial Support
The scheme for providing financial support for waste-to-energy projects is presently under review and accelerated programme on energy recovery from municipal and industrial wastes is being development for providing a major fillip to this sector.
Implementation
Waste-to-energy projects can be set up municipal corporations, other urban local bodies, government institutions, and private developers having technical and managerial capabilities for implementing such projects on the basis of Build, Own, and Operate (BOO); Build, Own, Operate, and Transfer (BOOT); Build, Operate, and Transfer (BOT); and Build, Operate, Lease, and Transfer (BOLT). The proposals are to be sent to the MNES after completing all tie-ups for waste procurement, sale and evacuation of power, pollution control, etc. In cases where debt financing is involved, IREDA, other financial institutions, and commercial banks are required to forward proposals alone with their Appraisal Note. An advance copy of the proposal may be sent to the MNES.
Cost
Gasification/pyrolysis 8-9
Potential
There exists a potential for generating an estimated 1700 MW of power from the urban and municipal waste, and about 1000 MW from industrial wastes in the country. The potential is likely to increase further with economic development.
Achievements
A total of 27 waste-to-energy projects have been completed as on 31 March 2005 in India, with an aggregated installed capacity of 45.50 MW. In table gives the state-wise cumulative achievements as on 31 March 2005.
Cumulative achievements as on 31 March 2005
State |
Achievement (MW) |
| Andhra Pradesh | 25.10 |
| Gujarat | 2.95 |
| Karnataka | 1.00 |
| Madhya Pradesh | 2.73 |
| Maharashtra | 1.90 |
| Orissa | 0.03 |
| Punjab | 1.75 |
| Tamil Nadu | 1.98 |
| Uttar Pradesh | 8.00 |
Total |
45.44 |
Main Application
Energy Recovery from Wastes
For further information please contact
Ministry of Non-Conventonal Energy Sources,
Govt. of India
Block-14, CGO Complex, Lodi Road
New Delhi – 110 003
Tel: 91 11 2436 0707/ 2436 0404
Fax: 91 11 2436 1298
